使用SAP型单级双吸中开泵的基本常识_0.docx

《使用SAP型单级双吸中开泵的基本常识_0.docx》由会员分享，可在线阅读，更多相关《使用SAP型单级双吸中开泵的基本常识_0.docx（11页珍藏版）》请在第壹文秘上搜索。

1、运用SAP型单级双吸中开泵的基本常以运用SAP型单级双吸中开泵的基本常识SAP型单级双吸中开泵的概述：SAP型系单级、双吸水平中开式离心泵，适应于工厂、城市、矿山、电站、农田、水利工程等领域。用于输送不含固体颗粒的清水或物理、化学性质类似于水的其它液体，被输送的介质温度为0C80C,允许最大进口压力0.6MPaSAP型单级双吸中开泵的结构型式：泵为卧式安装，泵壳于轴心线水平分开，上部为泵差，下部为泵体，吸入口和吐出口均在泵轴线下方的泵体上，其中心线与轴线垂直，检修时不需拆卸进水和出水管路，即可揭开泵釜，取出转子部件。除18SAP-30型泵为滑动轴承，其它型号泵轴承均采纳滚动轴承，轴承端盖密封采

2、纳骨架油封。左图为SAP型单级双吸中开泵示样图SAP型单级双吸中开泵的参数范围：流量Q7220000m/h扬程H6.8186mSAP型单级双吸中开泵的型号说明：例10-SAP-6A10-吸入口径被25除（即吸入口径为250mm）SAP-SA改进泵6-此转数被10除化整的约数A-叶轮外径变更SAP单级双吸中开泵的安装：1、 开箱后检查泵和电机，假如证明没有任何因装、卸和运输过程中造成的损坏和紧固连接件松动，泵的进出口封盖完好，无污物等进入泵内，则可干脆送到运用现场去安装。2、 安装泵的基础平面应用水平仪找平，待基础水泥凝固后，将泵安装在基础上，并用水平仪校正底座，应严格检查泵轴和电机轴的同心度，

3、联轴器外圆偏移允差0.1亳米，两联轴湍端面间隙一周上最大和最小的间隙差别不得超过0.3亳米。3、 泵的吸入管路和压出管路应设有支撑，不允许管路的雨量干脆由泵来承受，检查管路，仪表等接口处密封是否良好。泵可能发生的故障、缘由及解除方法：1、水泵不吸水：压力表及真空表的指针猛烈跳动缘由及解决方法：注入水泵的水不够：水泵或仪表漏气再往水泵内注水；拧紧或堵塞漏气处2、水泵不吸水，真空表显示高度真空缘由及解决方法：进水管路没有打开或已堵塞；吸水阻力太大：吸水高度太大而超过允许值。检查进水管路：清洗或更换吸水管：降低吸水高度3、看压力表水泵出水处有压力，而水泵仍不出水缘由及解决方法：出水管阻力太大：旋转方

4、向不对：叶轮淤塞：水泵转速不够o检雀或缩短出水管：变更电机转向；清洗叶轮：增加水泵轴的转速4、流量低于预料绿由及解决方法:水泵淤塞；密封环磨损过多：转速不够。清洗水泵及管道；更换密封环；增加水泵轴的转速5、水泵消耗的功率过大缘由及解决方法：填料压盖过紧；叶轮磨损：水泵供水量增加。拧松填料压盖或将填料取出打方；更换叶轮；调整闸阀降低流量6、水泵在工作过程中出现异样声音，流量下降宜到不出水：平衡装置早期磨损缘由及解决方法：闸阀开得太大：吸水管阻力太大：在吸水处有空气渗入；吸水高度过大：所输送液体温度过高调整闸阀以降低流量；检查吸水管道；检查底阀；削减吸水高度；拧紧或堵塞漏水处：降低液体温度7、水泵

5、振动缘由及解决方法：泵轴与电机轴线不在同一条中心线上把水泵和电机的轴中心线对准8轴承过热缘由及解决方法：没有油或油脏：水泵轴与电机轴不在一条中心线上/注油或换油：把轴中心线对准SAP型单级双吸中开泵的性能：参数型号流量Q3/h1./s扬程H转速n轴功率Pa配带电动机效率功率型号kw必需汽蚀余量叶轮名义直径进出口彳仝泵重mmr/minkw%mmmmmkg6SAP612618021635.050.060.0104978729804959.564.875Y280S-27380793.03.85.32701501001606SAP-611917020433.147.3. 74.725615010016

6、06SAP-6J729010820.025.030.02522.52014806.717.458.411Y160M-47374702.62.72.92701501001606SAP-810816019330.O44.553.5585450298024.42931.237Y2001.2-27081842.93.84.42051501001206SAP-8A10814417430.O40.O48.346443929801821.62330Y2001.1.-27680802.93.64.11851501001206SAP-8B10813316030.O36.944.5383632298015.517

7、1822Y180M-27277772.93.43.81701501001208SP-721628060.O77.89995298078.690.8132Y315M-274804. O4.727220012525533687.287IO1.796.O8SP-721026231458.472.887.2878374298068.27783.2I1.OY315S-27377764.O4.55.72552001252558SP-7B19624730054.468.683.476736329805764.671.575Y280S-27276724.O4.25.42402001252558SP-10194

8、28035153.977.897.5716352298052.159.365.475Y280S-27281762.84.15.32352001501808SP-1018025932450.O72.O90.O585241298040.64650.255Y250M-27079722.73.84.92172001501808SP-10B17323928848.O66.480.O48443629803236.73845Y225M-27078742.63.54.220020015018010SP-6432540720120.O150.O200.O9694891480162.6177.2215.5250Y

9、355M2-27478815.16.39.253025020086010SP-6A432540720120.O150.O200.O85.384761480129154.5186220Y355M1-477.680805.16.39.250025020086010SP-6B432540720120.O150.O200.O76.474671480121137.8164185Y355M-47479805.16.39.247025020086010SP-6J400500600111.1138.9166.742393598058.765.672.590Y315M-67881793.64.76.653025

10、020086010SP-6J30040050083.3111.1138.936.936339803949.65675Y315S-676.479803.33.64.750025020086010SP-6JB30040050083.3111.1138.933322898034.7444855Y280M-677.579793.33.64.747025020086010SP-6E400500600111.1138.9166.666.465.662.5148095.2113.1131160Y3151.1-47679784.65.77.544525020086012SP-4450540648125.O15

11、0.O180.O1441401351480245271301355Y400-47276792.32.73.2634300250155012SP-10610790900169.4219.4250.O595447.81480114132138160Y3151.1-48688854.14.65.1418300250107014SP-4800100O1200222.2277.8333.31861801671480544613696710Y450-474.58078.53.43.54.3724350250215014SP-1090010801260250.O300.O350.O7068641480206

12、.5230250280Y355-48387885.16.36.9466350300125014SP-10A90010801260250.O300.O350.O6058541480175196212250Y355-48487875.16.36.9440350300125014SP-10B90010801260250.0300.0350.05148441480148162180220Y355M-48487875.16.36.9425350300125014SP-10J650800100O180.6222.2277.830282498062.570.27790Y315M-68587844.O4.15

13、.14663503001250参数型号流量Q扬程H转速n轴功率Pa配带电动机效率功率必需汽蚀余量叶轮名义宜径进出口径泵重型号m3h1./smr/minkwkw%mmmmmkg14SP-10J600720900166.7200.0250.027252298052.55662.775Y315S-68487864.04.04.1440350300125014SAP-10JB600720900166.7200.0250.023211898044.2475275Y315S-68587854.04.04.1425350300125014SAP-10F450547684125.0151.9190.015.6

14、14.512.774222.825.127.537Y280S-884.86855.8440350300125014SAP-2087013201550241.7366.7430.6332621.51480101.5110111132Y315M-4778581.55.87.810.1340350300133016SAP-9J90010801260250.0300.0350.0424037980129140150185Y355M-68084854.64.95.2535400350198016SAP-9JA90010801260250.0300.0350.0373532980111.9122.5130

15、.7160Y315M-68184844.64.95.2510400350198016SAP-9JB8009001080222.2250.0300.033323098089.894102.6132Y315M-68083864.64.64.9480400350198016SAP-1011201400311.1388.991861480333370500Y400-483.388.85.96.453040035019801680466.77739688.97.516SAP-13110015001650305.6416.7458.358.550461480210234238280Y355-483.687.3 878.2445400350135020SP-4150020002730416.7555.6758.3171165140.6980949111214491600Y630-673.780.972.23.13.24.51050500400605020SP-5166720002400463.1555.6666.7130.4127.5120.6980812.8885.4957.4 1120Y500-672.878.1482.34.O4.86.O955500350375020SP-61